ISSN 1000-3304CN 11-1857/O6

Citation: Jin-rong Wang, Jian-feng Wang, Ying Zhu and Lei Jiang. Highly Transparent and Tough Clay/Poly(vinyl alcohol) Artificial Nacre[J]. Acta Polymerica Sinica, 2015, (3): 363-368. doi: 10.11777/j.issn1000-3304.2015.14390 shu

Highly Transparent and Tough Clay/Poly(vinyl alcohol) Artificial Nacre

  • Received Date: 2014-10-22
    Accepted Date: 2014-11-27
    Available Online: 2015-03-20

  • Inspired by the relationship between microstructure and mechanical properties of natural nacre, clay/poly(vinyl alcohol) artificial nacre was prepared through evaporation-induced assembly of poly(vinyl alcohol)/coated clay nanoplatelets. The clay loading in the artificial nacre is determined as 52 wt% by thermogravimetric analysis. A well-defined layered structure is proved by scanning electronic microscopy, transmission electronic microscopy and X-ray diffraction. FTIR proves that hydrogen bond is formed between clay and PVA. Tensile test results show that the strength of the artificial nacre is about (90.28.0) MPa, comparable to that of natural nacre (80~135 MPa). Importantly, the elongation at break and tensile toughness reach (14.72.3)% and (10.63.0) MJ/m3, respectively, which are much higher than those of the reported bio-inspired layered montmorillonite/polymer nanocomposites. The improved strength is attributed to the high clay loading, ordered layered structure and strong interfacial adhesion. Interestingly, appropriate aspect ratios of clay platelets enable the artificial nacre to fail in the form of clay platelet pull-out and thus leads to high toughness. In addition, the artificial nacre is transparent because of reduced light scattering, arising from ordered layered structure and small diameter of the used clay. The transparency of the artificial nacre is more than 90%.
  • 加载中
    1. [1]

      Espinosa H D, Rim J E, Barthelat F, Buehler M J.Prog Mater Sci, 2009, 54(8):1059~1100

    2. [2]

      Jackson A, Vincent J, Turner R.Proc Royal Soc London Ser B, 1988, 234(1277):415~440

    3. [3]

      Wang J, Cheng Q, Tang Z.Chem Soc Rev, 2012, 41(3):1111~1129

    4. [4]

      Yao H B, Ge J, Mao L B, Yan Y X, Yu S H.Adv Mater, 2014, 26(1):163~188

    5. [5]

      Cheng Q, Jiang L, Tang Z.Acc Chem Res, 2014, 47(4):1256~1266

    6. [6]

      Lu H, Chen Z, Ma C.J Mater Chem, 2012, 22(32):16182~16190

    7. [7]

      Yu, X W(于小雯), Shi, G Q(石高全).Acta Polymerica Sinica(高分子学报), 2014, (7):885-895.

    8. [8]

      Tang Z, Kotov N A, Magonov S, Ozturk B.Nat Mater, 2003, 2(6):413~418

    9. [9]

      Podsiadlo P, Liu Z, Paterson D, Messersmith P B, Kotov N A.Adv Mater, 2007, 19(7):949~955

    10. [10]

      Podsiadlo P, Kaushik A K, Arruda E M, Waas A M, Shim B S, Xu J, Nandivada H, Pumplin B G, Lahann J, Ramamoorthy A, Kotov N A.Science, 2007, 318(5847):80~83

    11. [11]

      Walther A, Bjurhager I, Malho J M, Pere J, Ruokolainen J, Berglund L A, Ikkala O.Nano Lett, 2010, 10(8):2742~2748

    12. [12]

      Yao H B, Tan Z H, Fang H Y, Yu S H.Angew Chem Int Ed, 2010, 49(52):10127~10131

    13. [13]

      Yao H B, Mao L B, Yan Y X, Cong H P, Lei X, Yu S H.ACS Nano, 2012, 6(9):8250~8260

    14. [14]

      Wang X, Bai H, Yao Z, Liu A, Shi G.J Mater Chem, 2010, 20(41):9032~9036

    15. [15]

      Laaksonen P, Walther A, Malho J M, Kainlauri M, Ikkala O, Linder M B.Angew Chem Int Ed, 2011, 50(37):8688~8691

    16. [16]

      Cheng Q, Wu M, Li M, Jiang L, Tang Z.Angew Chem Int Ed, 2013, 52(13):3750~3755

    17. [17]

      Hu X, Xu Z, Gao C.Sci Rep, 2012, 2:767

    18. [18]

      Zhao X, Xu Z, Zheng B, Gao C.Sci Rep, 2013, 3:3164

    19. [19]

      Liu Z, Xu Z, Hu X Z, Gao C.Macromoleculs, 2013, 46(17):6931~6941

    20. [20]

      Zhao Xiaoli(赵晓丽), Gao Chao(高超).Acta Polymerica Sinica(高分子学报), 2014, (10):1301~1313

    21. [21]

      Hu X, Xu Z, Liu Z, Gao C.Sci Rep, 2013, 3:2374

    22. [22]

      Wang J, Cheng Q, Lin L, Chen L, Jiang L.Nanoscale, 2013, 5(14):6356~6362

    23. [23]

      Wang J, Cheng Q, Lin L, Jiang L.ACS Nano, 2014, 8(3):2739~2745

    24. [24]

      Wang Y, Yu J, Chen L, Hu Z, Shi Z, Zhu J.RSC Adv, 2013, 3(43):20353~20362

    25. [25]

      Huang L, Li C, Yuan W J, Shi G Q.Nanoscale, 2013, 5(9):3780~3786

    26. [26]

      Barthelat F, Tang H.Zavattieri P D, Li C M, Espinosa H D.J Mech Phys Solids, 2007, 55(2):306~337

    27. [27]

      Podsiadlo P, Kaushik A K, Shim B S, Agarwal A, Tang Z, Waas A M, Arruda E M, Kotov N A.J Phys Chem B, 2008, 112(46):14359~14363

    28. [28]

      Vertlib V, Dietike M, Spolenak R, Puzrin A M.J Mater Res, 2008, 23(4):1026~1035

    29. [29]

      Han J, Dou Y, Yan D, Ma J, Wei M, Evans D G, Duan X.Chem Commun, 2011, 47(18):5274~5276

    30. [30]

      Wang R Z, Suo Z, Evans A G, Yao N, Aksay I A.J Mater Res, 2001, 16(9):2485~2493

    31. [31]

      Bonderer L J, Studart A R, Gauckler L J.Science, 2008, 319(5866):1069~1073

    32. [32]

      Sato H, Yamagishi A, Kawamura K.J Phys Chem B, 2001, 105(33):7990~7997

    33. [33]

      Yano H, Sugiyama J, Nakagaito A N, Nogi M, Matsuura T, Hikita M, Handa K.Adv Mater, 2005, 17(2):153~155

  • 加载中
    1. [1]

      Huai-yin RenMei-fang ZhuKazutoshi Haraguchi . MODIFICATION AND CHARACTERIZATION OF POLYMER/CLAY NANOCOMPOSITE HYDROGELS BY EXCHANGING WATER WITH ALCOHOLIC SOLVENTS. Acta Polymerica Sinica, 2012, (7): 689-693. doi: 10.3724/SP.J.1105.2012.12035

    2. [2]

      Yong-wei ChenRi-dong ZhangXin ChenXin-xing FengKan LaiLan ZhouJian-chun Zhang . Effects of Drawing on Crystalline Forms and Mechanical Properties of Nylon-6 Fiber. Acta Polymerica Sinica, 2014, (12): 1643-1647. doi: 10.11777/j.issn1000-3304.2014.14129

    3. [3]

      Wan-li GaoBao-shu ChenJia-bin ShenShao-yun Guo . Flame-retarding and Mechanical Properties of Alternating Multilayered Composites Consisting of PP and Flame Retardant Filled PP Layers. Acta Polymerica Sinica, 2014, (10): 1350-1355. doi: 10.11777/j.issn1000-3304.2014.14015

    4. [4]

      TAN JueZHENG YudongPENG JiangWU JianGAO ShuangTIAN RuCHEN Hongyan . PREPARATION AND MECHANICAL PROPERTIES OF LAYERED BC NANO-CELLULOSE MEMBRANE/PVA COMPOSITE HYDROGELS. Acta Polymerica Sinica, 2012, (4): 351-356. doi: 10.3724/SP.J.1105.2012.11171

    5. [5]

      Shu-yan YangZhi-xin JiaLan LiuYuan-fang LuoDe-min JiaZhi-meng Liu . Studies on Effects of Crosslinking Network Structure on Mechanical Properties of Natural Rubber by Freezing Point Depression Approach. Acta Polymerica Sinica, 2014, (7): 943-947. doi: 10.11777/j.issn1000-3304.2014.13411

    6. [6]

      Zi-ye ChenHeng-xue XiangZe-xu HuZhang-gen NiMei-fang Zhu . Enhanced Mechanical Properties of Melt-spun Bio-based PHBV Fibers:Effect of Heterogeneous Nucleation and Drawing Process. Acta Polymerica Sinica, 2017, (7): 1121-1129. doi: 10.11777/j.issn1000-3304.2017.16366

    7. [7]

      Yan YiZhang BinLi BaoWu Li-xin . Self-assembly and Photo-triggered Structural Transformation of Hybrid Polyanionic Clusters. Acta Polymerica Sinica, 2017, (1): 101-111. doi: 10.11777/j.issn1000-3304.2017.16245

    8. [8]

      ZHANG YueXU JunGUO Baohua . MICROSCOPIC STRUCTURE AND MECHANICAL PROPERTIES OF POLYLACTIDE/ATTAPULGITE NANOCOMPOSITES. Acta Polymerica Sinica, 2012, (1): 83-88. doi: 10.3724/SP.J.1105.2012.11070

    9. [9]

      Feng-hua ChenYan ZhangWei-chao ShiShi-yong YangXiao-juan ZhaoCharles C. Han . CURING AGENT INFLUENCE ON THE LAYERED-STRUCTURE FORMATION IN THE EPOXY/POLYSULFONE BLENDS. Acta Polymerica Sinica, 2012, (6): 673-678. doi: 10.3724/SP.J.1105.2012.11296

    10. [10]

      LV QiufengZHANG JiayinHE Zhiwei . SELF-ASSEMBLY PREPARATION AND PROPERTIES OF POLY(ANILINE-co-PYRROLE) HOLLOW SPHERES. Acta Polymerica Sinica, 2012, (3): 299-306. doi: 10.3724/SP.J.1105.2012.11190

    11. [11]

      Cui-ge ZhangYe ZhuJing LuoWei WeiYao GuXiao-ya Liu . Self-assembled Papain/HA-Phe Composite Nanoparticles and Emulsification Properties. Acta Polymerica Sinica, 2016, (7): 963-970. doi: 10.11777/j.issn1000-3304.2016.15350

    12. [12]

      Wen TangKan YueStephen Z. D. Cheng . Molecular Topology Effects in Self-assembly of Giant Surfactants. Acta Polymerica Sinica, 2018, 0(8): 959-972. doi: 10.11777/j.issn1000-3304.2018.18102

    13. [13]

      Wang Yan-yanFang FeiDing XinChen Xiao-xuanZheng KangChen LinTian Xing-youZhang Xian . Improvement of Flame Retardant Property of Cotton Fabric by Construction of Carbon Nanotube-based Hybrid Coating via Self-assembly. Acta Polymerica Sinica, 2016, (12): 1695-1703. doi: 10.11777/j.issn1000-3304.2016.16097

    14. [14]

      Jin WuQin WangShuang-feng TangChu-chun Yen . SYNTHESIS AND INVESTIGATION OF PHASE-SEPARATED LAMELLAR MORPHOLOGIES OF ROD-COIL TYPE POLYSTYRENE-b-POLY(-BENZYL-L-GLUTAMATE) POLYPEPTIDE HYBRIDS. Acta Polymerica Sinica, 2013, (9): 1151-1158. doi: 10.3724/SP.J.1105.2013.12389

    15. [15]

      Wei-yang LvWei-juan YeHua-kang FuMiao DuQiang Zheng . Studies on Poly(vinyl alcohol)/Layered Double Hydroxide in situ Composite Films. Acta Polymerica Sinica, 2015, (6): 699-705. doi: 10.11777/j.issn1000-3304.2015.14412

    16. [16]

      YU Zhi-ShengLI Yang . SYSTHESIS AND PERFORMANCES OF ABS RESIN TOUGHENED BY SIBR VIA BULK POLYMERIZATION METHODSTRUCTURE, PROPERTIES AND FRACTURE MECHNISM. Acta Polymerica Sinica, 2012, (4): 433-439. doi: 10.3724/SP.J.1105.2012.11229

    17. [17]

      Hao FuChang-fa XiaoLe-le SunJian PanQuan Quan . Structures and Properties of Poly(vinylidene fluoride-co-hexafluoropropylene) Fibers. Acta Polymerica Sinica, 2018, 0(5): 624-631. doi: 10.11777/j.issn1000-3004.2017.17158

    18. [18]

      LI Liang-ZhaoZHANG Xiu-QinLUO Fa-LiangZHAO YingWANG Du-Jin . STRUCTURE AND PROPERTIES OF iPP/MODIFIED NANO-CaCO3 COMPOSITES. Acta Polymerica Sinica, 2011, (10): 1218-1223. doi: 10.3724/SP.J.1105.2011.10334

    19. [19]

      Wang Zhi-liangLi Jie-fuNie JingYang Shu-guang . Effect of Hydrothermal Treatment on Structure and Properties of Polyamide 6 Fibers. Acta Polymerica Sinica, 2016, (12): 1710-1716. doi: 10.11777/j.issn1000-3304.2016.16109

    20. [20]

      Han-xiong HuangZe WuWei-sheng GuanBin Wang . STRUCTURE AND PROPERTIES OF PP/HNT NANOCOMPOSITE PARTS PREPARED BY MICRO-INJECTION MOLDING. Acta Polymerica Sinica, 2013, (12): 1514-1519. doi: 10.3724/SP.J.1105.2013.13116

Metrics
  • PDF Downloads(88)
  • Abstract views(159)
  • HTML views(15)
  • Cited By(0)

通讯作者: 陈斌, bchen63@163.com
  • 1. 

    沈阳化工大学材料科学与工程学院 沈阳 110142

  1. 本站搜索
  2. 百度学术搜索
  3. 万方数据库搜索
  4. CNKI搜索
Supported byBeijing Renhe Information Technology Co. Ltd Technical support: info@rhhz.net 百度统计

/

DownLoad:  Full-Size Img  PowerPoint
Return