Organic Solar Cells with an Efficiency Approaching 15%

Cui Yong; Yao Hui-feng; Yang Chen-yi; Zhang Shao-qing; Hou Jian-hui

doi:10.11777/j.issn1000-3304.2018.17297

您当前的位置：

首页 >

文章列表页 >

Organic Solar Cells with an Efficiency Approaching 15%

Research Article | 更新时间：2021-01-26

- Organic Solar Cells with an Efficiency Approaching 15%
  增强出版
- Acta Polymerica Sinica Issue 2, Pages: 223-230(2018)
- 作者机构：
  
  中国科学院化学研究所高分子物理与化学国家重点实验室北京 100190
- 作者简介：
- 基金信息：
- DOI：10.11777/j.issn1000-3304.2018.17297
  CLC：
- Published：20 February 2018，
  
  Received：26 October 2017，
  
  Revised：9 November 2017，
扫描看全文
Cui Yong, Yao Hui-feng, Yang Chen-yi, Zhang Shao-qing, Hou Jian-hui. Organic Solar Cells with an Efficiency Approaching 15%. [J]. Acta Polymerica Sinica (2):223-230(2018)
DOI：

Cui Yong, Yao Hui-feng, Yang Chen-yi, Zhang Shao-qing, Hou Jian-hui. Organic Solar Cells with an Efficiency Approaching 15%. [J]. Acta Polymerica Sinica (2):223-230(2018) DOI： 10.11777/j.issn1000-3304.2018.17297.

摘要

对叠层有机太阳能电池中的前、后子电池之间的光谱匹配性进行了优化调制.最终，选用带隙为1.24 eV的PTB7-Th：IEICO-4F作为后电池，带隙为1.59 eV的J52-2F：IT-M作为前电池制备了叠层电池.在这个叠层有机太阳能电池中，这2个子电池不仅具有互补的吸收光谱，还具有高的外量子效率，实现了对300~1000 nm范围内太阳发射光谱的高效利用.此外，前、后电池的能量损失均得到有效的控制，分别为0.64和0.53 eV.因此，从光伏性能具体参数上来看，本文制备的叠层器件兼具了高短路电流密度（

）和高开路电压（

）的优势，分别达到13.3 mA/cm

和1.65 V.该电池在本实验室内部测试的光伏效率高达14.9%，封装之后效率略有降低，由中国计量科学研究院（NIM）验证的光伏效率达到14.0%.这是目前有机光伏领域的国际最高结果.

Abstract

In this work

we focus on the fine-tuning of absorption spectra to achieve well-matched light response and reducing the energy loss (

loss

opt

-e

where

opt

is the optical bandgap

and

is the open circuit voltage) for the sub-cells of tandem organic solar cells (OSCs) to improve photovoltaic performance. We select PTB7-Th:IEICO-4F with a band gap of 1.24 eV as the rear cell and J52-2F:IT-M with a band gap of 1.59 eV as the front cell to fabricate the tandem OSCs. The absorption spectra of PTB7-Th:IEICO-4F is mainly located in the region of 600-950 nm

while that of J52-2F:IT-M is mainly located in the region of 450-750 nm. Their response spectra are very complementary

and both of the sub-cells show high external quantum efficiency

prompting the tandem OSCs to realize high-efficiency utilization of solar spectrum in the range of 300-1000 nm. In this tandem OSC

the

loss

in both front and rear cells are also effectively controlled to be 0.64 and 0.53 eV

respectively. In addition

an efficient interconnection layer (ICL) of ZnO/PCP-Na is used to connect the front and the rear sub-cells

which shows outstanding diode characteristics and high light transmittance in the long wavelength direction. In view of these excellent properties

the tandem solar cells manufactured in this work possess the advantages of high short-circuit current density (

) and

reaching 13.3 mA/cm

and 1.65 V

respectively. The highest power conversion efficiency (PCE) of the tandem OSC reaches 14.9%. The device parameters decrease slightly after encapsulation due to the intense ultraviolet irradiation

and a certified PCE of 14.0%

with a

of 1.64 V

of 12.9 mA/cm

and a fill factor (FF) of 0.664

recorded by National Institute of Metrology (NIM)

China. This result is the best obtained in the organic photovoltaic field.

关键词

有机太阳能电池聚合物太阳能电池非富勒烯叠层器件能量转换效率

Keywords

Organic solar cellsPolymer solar cellsNon-fullerene acceptorTandem solar cellHigh performance

references

M Kaltenbrunner , M S White , E D Glowacki , T Sekitani , T Someya , N S Sariciftci , S Bauer . Nat Commun , 2012 . 3 770 DOI:10.1038/ncomms1772http://doi.org/10.1038/ncomms1772.

A J Heeger . Adv Mater , 2014 . 26 10 - 27 . DOI:10.1002/adma.201304373http://doi.org/10.1002/adma.201304373.

F C Krebs . Sol Energy Mat Sol C , 2009 . 93 394 - 412 . DOI:10.1016/j.solmat.2008.10.004http://doi.org/10.1016/j.solmat.2008.10.004.

S Lizin , S Van Passel , E De Schepper , W Maes , L Lutsen , J Manca , D Vanderzande . Energy Environ Sci , 2013 . 6 3136 DOI:10.1039/c3ee42653jhttp://doi.org/10.1039/c3ee42653j.

Huifeng Yao , Jianhui Hou . Acta Polymerica Sinica , 2016 . ( 11 ): 1468 - 1481 . http://www.gfzxb.org/CN/abstract/abstract14665.shtml.

姚惠峰 , 侯剑辉 . 高分子学报 , 2016 . ( 11 ): 1468 - 1481 . http://www.gfzxb.org/CN/abstract/abstract14665.shtml.

W Zhao , S Li , H Yao , S Zhang , Y Zhang , B Yang , J Hou . J Am Chem Soc , 2017 . 139 7148 - 7151 . DOI:10.1021/jacs.7b02677http://doi.org/10.1021/jacs.7b02677.

T Ameri , N Li , C J Brabec . Energy Environ Sci , 2013 . 6 2390 DOI:10.1039/c3ee40388bhttp://doi.org/10.1039/c3ee40388b.

M Li , K Gao , X Wan , Q Zhang , B Kan , R Xia , F Liu , X Yang , H Feng , W Ni , Y Wang , J Peng , H Zhang , Z Liang , H L Yip , X Peng , Y Cao , Y Chen . Nat Photon , 2016 . 11 85 - 90.

Y Cui , H Yao , B Gao , Y Qin , S Zhang , B Yang , C He , B Xu , J Hou . J Am Chem Soc , 2017 . 139 7302 - 7309 . DOI:10.1021/jacs.7b01493http://doi.org/10.1021/jacs.7b01493.

Z Zheng , S Zhang , J Zhang , Y Qin , W Li , R Yu , Z Wei , J Hou . Adv Mater , 2016 . 28 5133 - 5138 . DOI:10.1002/adma.201600373http://doi.org/10.1002/adma.201600373.

C C Chen , W H Chang , K Yoshimura , K Ohya , J You , J Gao , Z Hong , Y Yang . Adv Mater , 2014 . 26 5670 - 5677 . DOI:10.1002/adma.201402072http://doi.org/10.1002/adma.201402072.

J Gilot , M M Wienk , R A J Janssen . Adv Funct Mater , 2010 . 20 3904 - 3911 . DOI:10.1002/adfm.201001167http://doi.org/10.1002/adfm.201001167.

K Zhang , K Gao , R Xia , Z Wu , C Sun , J Cao , L Qian , W Li , S Liu , F Huang , X Peng , L Ding , H L Yip , Y Cao . Adv Mater , 2016 . 28 4817 - 4823 . DOI:10.1002/adma.v28.24http://doi.org/10.1002/adma.v28.24.

A R b M Yusoff , D Kim , H P Kim , F K Shneider , Silva W J da , J Jang . Energy Environ Sci , 2015 . 8 303 - 316 . DOI:10.1039/C4EE03048Fhttp://doi.org/10.1039/C4EE03048F.

S Lu , X Guan , X Li , W E I Sha , F Xie , H Liu , J Wang , F Huang , W C H Choy . Adv Energy Mater , 2015 . 5 1500631 DOI:10.1002/aenm.201500631http://doi.org/10.1002/aenm.201500631.

H Yao , Y Chen , Y Qin , R Yu , Y Cui , B Yang , S Li , K Zhang , J Hou . Adv Mater , 2016 . 28 8283 - 8287 . DOI:10.1002/adma.v28.37http://doi.org/10.1002/adma.v28.37.

J Liu , S Chen , D Qian , B Gautam , G Yang , J Zhao , J Bergqvist , F Zhang , W Ma , H Ade , O Inganäs , K Gundogdu , F Gao , H Yan . Nat Energy , 2016 . 1 16089 DOI:10.1038/nenergy.2016.89http://doi.org/10.1038/nenergy.2016.89.

N Liang , D Meng , Z Ma , B Kan , X Meng , Z Zheng , W Jiang , Y Li , X Wan , J Hou , W Ma , Y Chen , Z Wang . Adv Energy Mater , 2017 . 7 1601664 DOI:10.1002/aenm.201601664http://doi.org/10.1002/aenm.201601664.

Y Lin , J Wang , Z G Zhang , H Bai , Y Li , D Zhu , X Zhan . Adv Mater , 2015 . 27 1170 - 1174 . DOI:10.1002/adma.201404317http://doi.org/10.1002/adma.201404317.

F Yang , C Li , W Lai , A Zhang , H Huang , W Li . Mater Chem Front , 2017 . 1 1389 - 1395 . DOI:10.1039/C7QM00025Ahttp://doi.org/10.1039/C7QM00025A.

W Zhao , D Qian , S Zhang , S Li , O Inganas , F Gao , J Hou . Adv Mater , 2016 . 28 4734 - 4739 . DOI:10.1002/adma.v28.23http://doi.org/10.1002/adma.v28.23.

W Liu , S Li , J Huang , S Yang , J Chen , L Zuo , M Shi , X Zhan , C Z Li , H Chen . Adv Mater , 2016 . 28 9729 - 9734 . DOI:10.1002/adma.201603518http://doi.org/10.1002/adma.201603518.

S Chen , G Zhang , J Liu , H Yao , J Zhang , T Ma , Z Li , H Yan . Adv Mater , 2017 . 29 1604231 DOI:10.1002/adma.201604231http://doi.org/10.1002/adma.201604231.

Q Fan , W Su , X Meng , X Guo , G Li , W Ma , M Zhang , Y Li . Solar RRL , 2017 . 1 1700020 DOI:10.1002/solr.v1.5http://doi.org/10.1002/solr.v1.5.

D Qian , L Ye , M Zhang , Y Liang , L Li , Y Huang , X Guo , S Zhang , Z Tan , J Hou . Macromolecules , 2012 . 45 9611 - 9617 . DOI:10.1021/ma301900hhttp://doi.org/10.1021/ma301900h.

H Yao , Y Cui , R Yu , B Gao , H Zhang , J Hou . Angew Chem Int Ed , 2017 . 56 3045 - 3049 . DOI:10.1002/anie.201610944http://doi.org/10.1002/anie.201610944.

Y Cui , B Xu , B Yang , H Yao , S Li , J Hou . Macromolecules , 2016 . 49 8126 - 8133 . DOI:10.1021/acs.macromol.6b01595http://doi.org/10.1021/acs.macromol.6b01595.

S Li , L Ye , W Zhao , S Zhang , S Mukherjee , H Ade , J Hou . Adv Mater , 2016 . 28 9423 - 9429 . DOI:10.1002/adma.201602776http://doi.org/10.1002/adma.201602776.

S H Liao , H J Jhuo , Y S Cheng , S A Chen . Adv Mater , 2013 . 25 4766 - 4771 . DOI:10.1002/adma.v25.34http://doi.org/10.1002/adma.v25.34.

F Huang , H B Wu , D Wang , W Yang , Y Cao . Chem Mater , 2004 . 16 708 - 716 . DOI:10.1021/cm034650ohttp://doi.org/10.1021/cm034650o.

更多指标>

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Design, Synthesis, and Performance Study of Polymer Donor Materials with Alkyne Bonds in Organic Solar Cells

Insulating Polymer Additives for Improving the Efficiency and Stability of Organic Solar Cells

Synthesis and Properties of a Conjugated Acceptor Material for Organic Solar Cells Based on Indacenobis(dithieno[3,2-b:2′,3′-d]pyran)

Overview and Outlook of Random Copolymerization Strategy for Designing Polymer Solar Cells

Synthesis and Photovoltaic Performance of Low Band Gap Dithieno[3, 2-b:2', 3'-d]pyrrole-based Conjugated Copolymers

Related Author

No data

Related Institution

College of Textiles & Clothing, State Key Laboratory of Bio-fibers and Eco-textiles, Qingdao University

Beijing Key Laboratory of Energy Conversion and Storage Materials, College of Chemistry, Beijing Normal University

School of Materials, Sun Yat-sen University

State Key Laboratory and Institute of Elemento-Organic Chemistry, Centre of Nanoscale Science and Technology, Key Laboratory of Functional Polymer Materials, College of Chemistry, Nankai University

南昌大学化学学院

Postal code：100190
Tel：010-62588927 Email：gfzxb@iccas.ac.cn
Technical support is provided by Beijing Founder electronics co., LTD 京ICP备05002797号-8 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰