Evolution of Conductive Network in Nickel/Polyurethane Composites under Tensile Strain

Ke Tian; Hua Deng; Qiang Fu

doi:10.11777/j.issn1000-3304.2020.19228

您当前的位置：

首页 >

文章列表页 >

Evolution of Conductive Network in Nickel/Polyurethane Composites under Tensile Strain

更新时间：2021-01-26

- Evolution of Conductive Network in Nickel/Polyurethane Composites under Tensile Strain
- Acta Polymerica Sinica Vol. 51, Issue 5, Pages: 559-568(2020)
- 作者机构：
  
  四川大学高分子科学与工程学院高分子材料工程国家重点实验室　成都 610065
- 作者简介：
- 基金信息：
- DOI：10.11777/j.issn1000-3304.2020.19228
  CLC：
- Published：2020-5，
  
  Published Online：24 March 2020，
  
  Received：30 December 2019，
  
  Revised：1 February 2020，
扫描看全文
Ke Tian, Hua Deng, Qiang Fu. Evolution of Conductive Network in Nickel/Polyurethane Composites under Tensile Strain. [J]. Acta Polymerica Sinica 51(5):559-568(2020)
DOI：

Ke Tian, Hua Deng, Qiang Fu. Evolution of Conductive Network in Nickel/Polyurethane Composites under Tensile Strain. [J]. Acta Polymerica Sinica 51(5):559-568(2020) DOI： 10.11777/j.issn1000-3304.2020.19228.

摘要

一种独特的电性能形变敏感行为—镍/聚氨酯复合材料的电阻率在20%拉伸应变下呈现近6个数量级的降低，导致该行为的填料网络演变机理仍不清晰. 针对该现象，本文通过交流阻抗分析考察了2种具有不同拉伸敏感特性的镍/聚氨酯复合材料体系在不同应变下各种微观参数对频率的依赖性. 采用尼奎斯特曲线拟合得到的数据及参数计算了团聚体电阻、团聚体之间电阻在拉伸下的变化，以此推测了2种复合材料体系在拉伸时导电网络不同的变化模式. 结果表明，对于27.5 vol%填料含量的复合材料，在拉伸时由于团聚体维度发生变化使得逾渗在拉伸下发生，即拉伸逾渗现象. 而25 vol%填料含量的复合材料由于填料含量远低于逾渗区域，即使团聚体维度发生变化也没有连续的导电网络产生. 本工作为导电高分子复合材料在拉伸时导电网络的变化提供了新的理解，并为拉伸敏感导电高分子复合材料的网络研究提供新的思路.

Abstract

An unconventional resistivity-strain behavior — the resistivity of nickel/polyurethane composites decreases by more than six orders of magnitude under 20% tensile strain was observed for the first time

while the conductive network evolution mechanism responsible for such unusual behavior is still unclear. In this work

the frequency dependence of various parameters of two nickel/polyurethane composite systems with contrary strain sensing behaviors was investigated by means of impedance spectra (IS) to achieve better understanding. Through further analysis using fitting parameters of Nyquist plot

the changes in the resistance of aggregates and the resistance between aggregates under tension were calculated and two different evolution modes of conductive network for both composite systems were proposed. It is illustrated that the percolation behavior occurred under tension for the composite with 27.5 vol% filler concentration due to the dimensional change of these aggregates

which is named as stretch-induced percolation. However

no continuous conductive network is constructed in the matrix within the whole strain range for composite with 25 vol% filler loading

because such content is much lower than that in the percolation region. This study provides a new understanding for the variation in conductive network of conductive polymer composites (CPCs) during stretching

and offers a new strategy to investigate the evolution of conductive network in CPCs.

关键词

导电网络阻抗分析团聚体电阻团聚体之间电阻拉伸逾渗

Keywords

Conductive networkImpedance spectraResistance in aggregateResistance between aggregatesStretch-induced percolation

references

Wang X, Sparkman J, Gou J. Compos Commun , 2017 . 3 1 - 6 . DOI:10.1016/j.coco.2016.10.003http://doi.org/10.1016/j.coco.2016.10.003 .

Tripathi K M, Vincent F, Castro M, Feller J F. Nanocomposites , 2016 . 2 ( 3 ): 125 - 134 . DOI:10.1080/20550324.2016.1227546http://doi.org/10.1080/20550324.2016.1227546 .

Meng X, Zhao S, Zhang Z, Zhang R, Li J, Leng J, Cao D, Zhang G, Sun R. J Mater Chem C , 2019 . 7 ( 23 ): 7061 - 7072 . DOI:10.1039/C9TC00943Dhttp://doi.org/10.1039/C9TC00943D .

Wang R, Xu W, Shen W, Shi X, Huang J, Song W. Inorg Chem Front , 2019 . 6 ( 11 ): 3119 - 3124 . DOI:10.1039/C9QI00989Bhttp://doi.org/10.1039/C9QI00989B .

Shen Z, Feng J. J Mater Chem C , 2019 . 7 ( 30 ): 9423 - 9429 . DOI:10.1039/C9TC02321Fhttp://doi.org/10.1039/C9TC02321F .

Lee D W, Lee J H, Jin J H. Compos Struct , 2018 . 204 487 - 499 . DOI:10.1016/j.compstruct.2018.07.131http://doi.org/10.1016/j.compstruct.2018.07.131 .

Lin L, Liu S, Fu S, Zhang S, Deng H, Fu Q. Small , 2013 . 9 ( 21 ): 3620 - 3629 . DOI:10.1002/smll.201202306http://doi.org/10.1002/smll.201202306 .

Lamberti A, Garino N, Sacco A, Bianco S, Manfredi D, Gerbaldi C. Electrochim Acta , 2013 . 102 233 - 239 . DOI:10.1016/j.electacta.2013.04.014http://doi.org/10.1016/j.electacta.2013.04.014 .

Wang Y J, Pan Y, Zhang X W, Tan K. J Appl Polym Sci , 2005 . 98 ( 3 ): 1344 - 1350 . DOI:10.1002/app.22297http://doi.org/10.1002/app.22297 .

Stassi S, Sacco A, Canavese G. J Phys D: Appl Phys , 2014 . 47 345306 - 345311 . DOI:10.1088/0022-3727/47/34/345306http://doi.org/10.1088/0022-3727/47/34/345306 .

Chen Z, Pfattner R, Bao Z. Adv Electron Mater , 2017 . 3 ( 1 ): 1600397 - 1600404 . DOI:10.1002/aelm.201600397http://doi.org/10.1002/aelm.201600397 .

Han B, Wang Y, Sun S, Yu X, Ou J. Compos Part A Appl Sci Manuf , 2014 . 59 105 - 114 . DOI:10.1016/j.compositesa.2014.01.005http://doi.org/10.1016/j.compositesa.2014.01.005 .

Lee D, Kim J, Kim H, Heo H, Park K, Lee Y. Nanoscale , 2018 . 10 ( 39 ): 18812 - 18820 . DOI:10.1039/C8NR05843Ahttp://doi.org/10.1039/C8NR05843A .

Li Z, Ye L, Shen J, Xie K, Li Y. Compos Commun , 2018 . 7 23 - 29 . DOI:10.1016/j.coco.2017.12.007http://doi.org/10.1016/j.coco.2017.12.007 .

Zhang H, Bilotti E, Peijs T. Nanocomposites , 2015 . 1 ( 4 ): 167 - 184 . DOI:10.1080/20550324.2015.1113639http://doi.org/10.1080/20550324.2015.1113639 .

Saji J, Khare A, Choudhary R N P, Mahapatra S P. J Elastomers Plast , 2015 . 47 ( 5 ): 394 - 415 . DOI:10.1177/0095244313514991http://doi.org/10.1177/0095244313514991 .

Saji J, Khare A, Mahapatra S P. Fibers Polym , 2015 . 16 ( 4 ): 883 - 893 . DOI:10.1007/s12221-015-0883-2http://doi.org/10.1007/s12221-015-0883-2 .

Sun D, Wei Y. J Appl Polym Sci , 2008 . 108 ( 6 ): 3748 - 3752 . DOI:10.1002/app.27930http://doi.org/10.1002/app.27930 .

Loyola B R, La Saponara V, Loh K J. J Mater Sci , 2010 . 45 ( 24 ): 6786 - 6798 . DOI:10.1007/s10853-010-4775-yhttp://doi.org/10.1007/s10853-010-4775-y .

Bao H D, Sun Y, Xiong Z Y, Guo Z X, Yu J. J Appl Polym Sci , 2013 . 128 ( 1 ): 735 - 740 . DOI:10.1002/app.37554http://doi.org/10.1002/app.37554 .

Ke K, Poetschke P, Wiegand N, Krause B, Voit B. ACS Appl Mater Interfaces , 2016 . 8 ( 22 ): 14190 - 14199.

Zare Y, Garmabi H, Rhee K Y. Mater Chem Phys , 2018 . 206 243 - 250 . DOI:10.1016/j.matchemphys.2017.11.017http://doi.org/10.1016/j.matchemphys.2017.11.017 .

Zare Y, Rhee K Y. Compos Sci Technol , 2018 . 155 252 - 260 . DOI:10.1016/j.compscitech.2017.10.007http://doi.org/10.1016/j.compscitech.2017.10.007 .

更多指标>

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

No data

Related Author

No data

Related Institution

No data

Postal code：100190
Tel：010-62588927 Email：gfzxb@iccas.ac.cn
Technical support is provided by Beijing Founder electronics co., LTD 京ICP备05002797号-8 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰