Perpendicular Orientation of Polydimethylsiloxane Nanocylinders in Thin Film of a Liquid Crystalline Block Copolymer Induced by Unpolarized Light

Yu-jie Li; Long-fei Luo; Zhi-hao Shen; Xing-he Fan; Shi-jun Zheng

doi:10.11777/j.issn1000-3304.2021.21158

您当前的位置：

首页 >

文章列表页 >

Perpendicular Orientation of Polydimethylsiloxane Nanocylinders in Thin Film of a Liquid Crystalline Block Copolymer Induced by Unpolarized Light

Research Article | 更新时间：2023-05-22

- Perpendicular Orientation of Polydimethylsiloxane Nanocylinders in Thin Film of a Liquid Crystalline Block Copolymer Induced by Unpolarized Light
- ACTA POLYMERICA SINICA Vol. 52, Issue 12, Pages: 1611-1621(2021)
- 作者机构：
  
  1.郑州大学材料科学与工程学院　郑州 450001
  2.北京分子科学国家研究中心高分子化学与物理教育部重点实验室北京大学软物质科学与工程中心北京大学化学与分子工程学院　北京 100871
- 作者简介：
  
  Zhi-hao Shen, E-mail: zshen@pku.edu.cn
  Zhi-hao Shen, E-mail: zshen@pku.edu.cn
- 基金信息：
- DOI：10.11777/j.issn1000-3304.2021.21158
  CLC：
- Published：20 December 2021，
  
  Published Online：07 September 2021，
  
  Received：23 May 2021，
  
  Revised：30 June 2021，
扫描看全文
李玉洁,罗龙飞,沈志豪等.非偏振光诱导含聚二甲基硅氧烷的偶氮苯液晶嵌段共聚物薄膜微相分离结构的垂直取向[J].高分子学报,2021,52(12):1611-1621.

Li Yu-jie,Luo Long-fei,Shen Zhi-hao,et al.Perpendicular Orientation of Polydimethylsiloxane Nanocylinders in Thin Film of a Liquid Crystalline Block Copolymer Induced by Unpolarized Light[J].ACTA POLYMERICA SINICA,2021,52(12):1611-1621.
李玉洁,罗龙飞,沈志豪等.非偏振光诱导含聚二甲基硅氧烷的偶氮苯液晶嵌段共聚物薄膜微相分离结构的垂直取向[J].高分子学报,2021,52(12):1611-1621. DOI： 10.11777/j.issn1000-3304.2021.21158.

Li Yu-jie,Luo Long-fei,Shen Zhi-hao,et al.Perpendicular Orientation of Polydimethylsiloxane Nanocylinders in Thin Film of a Liquid Crystalline Block Copolymer Induced by Unpolarized Light[J].ACTA POLYMERICA SINICA,2021,52(12):1611-1621. DOI： 10.11777/j.issn1000-3304.2021.21158.

摘要

通过原子转移自由基聚合(ATRP)合成了聚二甲基硅氧烷-嵌段-聚(11-(4-(4'-氰基偶氮苯)苯氧基)十一烷基丙烯酸酯)(PDMS-

-PAz)的二嵌段共聚物，其中PDMS的体积分数是27%. 利用原子力显微镜和掠入射小角X射线散射等表征手段研究了不同厚度的薄膜分别在热退火和非偏振光取向后的组装形貌. 结果显示：热退火时，当膜厚较低时，形成的是面内无序排列的柱状结构；而当膜厚增加到319 nm时，形成的是面内排列与垂直于基底排列共存的杂化结构，即使当膜厚增加至406 nm时，这种杂化结构仍然保持. 而采用非偏振光取向时，即使对于厚度仅为55 nm的薄膜就能获得垂直于基底排列的微相分离结构，且当膜厚增加至406 nm时，这种结构仍然得到保持. 这是首次利用非偏振光诱导含PDMS的嵌段共聚物薄膜取向得到PDMS纳米柱垂直于基底的排列，这一取向方法将有助于推动含PDMS的嵌段共聚物薄膜在纳米模板等领域中的应用.

Abstract

A diblock copolymer containing polydimethylsiloxane and an azobenzene-based liquid crystalline polymer

PDMS-

-PAz

was synthesized by atom transfer radical polymerization (ATRP). The volume fraction of PDMS was 27%. Atomic force microscopy (AFM) and grazing-incidence small-angle X-ray scattering (GI-SAXS) were used to investigate the morphologies of thin films with different thicknesses after thermal annealing and unpolarized light orientation. The results show that the disordered cylindrical structure is formed in thinner films during thermal annealing. However

when the film thickness is increased to 319 nm

a coexistence of in-plane and out-of-plane arranged PDMS nanocylinders were observed. Even when the film thickness is increased to 406 nm

this coexistent state still remains. The microphase-separated structure perpendicular to the substrate can be obtained even for the thin film with a thickness of only 55 nm when being aligned with unpolarized light

and this structure is maintained when the film thickness is increased to 406 nm. This is the first time that the perpendicular orientation of PDMS nanocylinders in block copolymer films is obtained by the alignment of unpolarized light. This orientation method will benefit the application of PDMS-containing block copolymer films in nanotemplates and other fields.

关键词

嵌段共聚物偶氮苯液晶高分子聚二甲基硅氧烷非偏振光取向

Keywords

Block copolymerAzobenzene-based liquid crystalline polymerPolydimethylsiloxaneUnpolarized light orientation

references

Park M, Harrison C, Chaikin P M, Register R A, Adamson D H. Science, 1997, 276(5317): 1401-1404. doi:10.1126/science.276.5317.1401http://dx.doi.org/10.1126/science.276.5317.1401

Bita I, Yang J K W, Jung Y S, Ross C A, Thomas E L, Berggren K K. Science, 2008, 321(5891): 939-943. doi:10.1126/science.1159352http://dx.doi.org/10.1126/science.1159352

Li P, Wang Z, Li W, Liu Y, Wang J, Wang S. ACS Appl Mater Interfaces, 2015, 7(28): 15481-15493. doi:10.1021/acsami.5b03786http://dx.doi.org/10.1021/acsami.5b03786

Sheng J, Zhang M, Xu Y, Yu J, Ding B. ACS Appl Mater Interfaces, 2016, 8(40): 27218-27226. doi:10.1021/acsami.6b09392http://dx.doi.org/10.1021/acsami.6b09392

McDonald J C, Whitesides G M. Acc Chem Res, 2002, 35(7): 491-499. doi:10.1021/ar010110qhttp://dx.doi.org/10.1021/ar010110q

McDonald J C, Duffy D C, Anderson J R, Chiu D T, Wu H, Schueller O J A, Whitesides G M. Electrophoresis, 2000, 21(1): 27-40. doi:10.1002/(sici)1522-2683(20000101)21:1<27::aid-elps27>3.0.co;2-chttp://dx.doi.org/10.1002/(sici)1522-2683(20000101)21:1<27::aid-elps27>3.0.co;2-c

Liberman-Martin A L, Chu C K, Grubbs R H. Macromol Rapid Commun, 2017, 38(13): 1700058. doi:10.1002/marc.201700058http://dx.doi.org/10.1002/marc.201700058

Sinturel C, Bates F S, Hillmyer M A. ACS Macro Lett, 2015, 4(9): 1044-1050. doi:10.1021/acsmacrolett.5b00472http://dx.doi.org/10.1021/acsmacrolett.5b00472

Huang M, Yue K, Huang J, Liu C, Zhou Z, Wang J, Wu K, Shan W, Shi A C, Cheng S Z D. ACS Nano, 2018, 12(2): 1868-1877. doi:10.1021/acsnano.7b08687http://dx.doi.org/10.1021/acsnano.7b08687

Lo T Y, Krishnan M R, Lu K Y, Ho R M. Prog Polym Sci, 2018, 77: 19-68. doi:10.1016/j.progpolymsci.2017.10.002http://dx.doi.org/10.1016/j.progpolymsci.2017.10.002

Aissou K, Mumtaz M, Fleury G, Portale G, Navarro C, Cloutet E, Brochon C, Ross C A, Hadziioannou G. Adv Mater, 2015, 27(2): 261-265. doi:10.1002/adma.201404077http://dx.doi.org/10.1002/adma.201404077

Chuang V P, Ross C A, Gwyther J, Manners I. Adv Mater, 2009, 21(37): 3789-3793. doi:10.1002/adma.200900756http://dx.doi.org/10.1002/adma.200900756

Jung Y S, Ross C A. Nano Lett, 2007, 7(7): 2046-2050. doi:10.1021/nl070924lhttp://dx.doi.org/10.1021/nl070924l

Luo Y, Montarnal D, Kim S, Shi W, Barteau K P, Pester C W, Hustad P D, Christianson M D, Fredrickson G H, Kramer E J, Hawker C J. Macromolecules, 2015, 48(11): 3422-3430. doi:10.1021/acs.macromol.5b00518http://dx.doi.org/10.1021/acs.macromol.5b00518

Chao C C, Wang T C, Ho R M, Georgopanos P, Avgeropoulos A, Thomas E L. ACS Nano, 2010, 4(4): 2088-2094. doi:10.1021/nn901370ghttp://dx.doi.org/10.1021/nn901370g

Jung Y S, Lee J H, Lee J Y, Ross C A. Nano Lett, 2010, 10(9): 3722-3726. doi:10.1021/nl1023518http://dx.doi.org/10.1021/nl1023518

Guan Y, Xu F, Wang X, Hui Y, Sha J, Tian Y, Wang Z, Zhang S, Chen D, Yang L. Microelectron Eng, 2021, 235: 111455. doi:10.1016/j.mee.2020.111455http://dx.doi.org/10.1016/j.mee.2020.111455

Liu K, Yang C M, Yang B M, Zhang L, Huang W C, Ouyang X P, Qi F G, Zhao N, Bian F G. Chinese J Polym Sci, 2020, 38(1): 92-99. doi:10.1007/s10118-019-2315-zhttp://dx.doi.org/10.1007/s10118-019-2315-z

Kim E, Kim W, Lee K H, Ross C A, Son J G. Adv Funct Mater, 2014, 24(44): 6981-6988. doi:10.1002/adfm.201401678http://dx.doi.org/10.1002/adfm.201401678

Kato T, Mizoshita N, Kishimoto K. Angew Chem Int Ed, 2006, 45(1): 38-68. doi:10.1002/anie.200501384http://dx.doi.org/10.1002/anie.200501384

Tschierske C. Chem Soc Rev, 2007, 36(12): 1930-1970. doi:10.1039/b615517khttp://dx.doi.org/10.1039/b615517k

Mukai K, Hara M, Nagano S, Seki T. Angew Chem Int Ed, 2016, 55(45): 14028-14032. doi:10.1002/anie.201607786http://dx.doi.org/10.1002/anie.201607786

Kao J, Thorkelsson K, Bai P, Rancatore B J, Xu T. Chem Soc Rev, 2013, 42(7): 2654-2678. doi:10.1039/c2cs35375jhttp://dx.doi.org/10.1039/c2cs35375j

Pathiranage T M S K, Kim M, Nguyen H Q, Washington K E, Biewer M C, Stefan M C. Macromolecules, 2016, 49(18): 6846-6857. doi:10.1021/acs.macromol.6b01378http://dx.doi.org/10.1021/acs.macromol.6b01378

Hamley I W, Castelletto V, Lu Z B, Imrie C T, Itoh T, Al-Hussein M. Macromolecules, 2004, 37(13): 4798-4807. doi:10.1021/ma0498619http://dx.doi.org/10.1021/ma0498619

Yu H, Iyoda T, Ikeda T. J Am Chem Soc, 2006, 128(34): 11010-11011. doi:10.1021/ja064148fhttp://dx.doi.org/10.1021/ja064148f

Yu H, Li J, Ikeda T, Iyoda T. Adv Mater, 2006, 18(17): 2213-2215. doi:10.1002/adma.200600582http://dx.doi.org/10.1002/adma.200600582

Li J, Kamata K, Komura M, Yamada T, Yoshida H, Iyoda T. Macromolecules, 2007, 40(23): 8125-8128. doi:10.1021/ma071821shttp://dx.doi.org/10.1021/ma071821s

Morikawa Y, Kondo T, Nagano S, Seki T. Chem Mater, 2007, 19(7): 1540-1542. doi:10.1021/cm0630845http://dx.doi.org/10.1021/cm0630845

Yu H, Kobayashi T, Hu G H. Polymer, 2011, 52(7): 1554-1561. doi:10.1016/j.polymer.2011.01.053http://dx.doi.org/10.1016/j.polymer.2011.01.053

Wang T, Li X, Dong Z, Huang S, Yu H. ACS Appl Mater Interfaces, 2017, 9(29): 24864-24872. doi:10.1021/acsami.7b06086http://dx.doi.org/10.1021/acsami.7b06086

Luo L, Lyu X, Tang Z, Shen Z, Fan X H. Macromolecules, 2020, 53(21): 9619-9630. doi:10.1021/acs.macromol.0c01063http://dx.doi.org/10.1021/acs.macromol.0c01063

Tian C, Zhou K C, Lu Y F, Li J J, Yao Y, Tao X F, Zhuang Q X, Xie Y F, Lin S L. Chinese J Polym Sci, 2021, 39: 1169-1176. doi:10.1007/s10118-021-2576-1http://dx.doi.org/10.1007/s10118-021-2576-1

Yu H. Prog Polym Sci, 2014, 39(4): 781-815. doi:10.1016/j.progpolymsci.2013.08.005http://dx.doi.org/10.1016/j.progpolymsci.2013.08.005

Yu H, Ikeda T. Adv Mater, 2011, 23(19): 2149-2180. doi:10.1002/adma.201100131http://dx.doi.org/10.1002/adma.201100131

Nagano S, Koizuka Y, Murase T, Sano M, Shinohara Y, Amemiya Y, Seki T. Angew Chem Int Ed, 2012, 51(24): 5884-5888. doi:10.1002/anie.201201346http://dx.doi.org/10.1002/anie.201201346

Sano M, Nakamura S, Hara M, Nagano S, Shinohara Y, Amemiya Y, Seki T. Macromolecules, 2014, 47(20): 7178-7186. doi:10.1021/ma501803ghttp://dx.doi.org/10.1021/ma501803g

Li W, Müller M. Prog Polym Sci, 2016, 54-55: 47-75. doi:10.1016/j.progpolymsci.2015.10.008http://dx.doi.org/10.1016/j.progpolymsci.2015.10.008

Russell T P, Chai Y. Macromolecules, 2017, 50(12): 4597-4609. doi:10.1021/acs.macromol.7b00418http://dx.doi.org/10.1021/acs.macromol.7b00418

Ji S, Wan L, Liu C C, Nealey P F. Prog Polym Sci, 2016, 54-55: 76-127. doi:10.1016/j.progpolymsci.2015.10.006http://dx.doi.org/10.1016/j.progpolymsci.2015.10.006

Wei R, He Y, Wang X. RSC Adv, 2014, 4(102): 58386-58396. doi:10.1039/c4ra09863chttp://dx.doi.org/10.1039/c4ra09863c

Okano K. Jpn J Appl Phys, 1983, 22(Part 2, No. 6): L343-L344. doi:10.1143/jjap.22.l343http://dx.doi.org/10.1143/jjap.22.l343

Kimura H, Nakano H. J Phys Soc Jpn, 1985, 54(5): 1730-1736. doi:10.1143/jpsj.54.1730http://dx.doi.org/10.1143/jpsj.54.1730

Nagano S. Langmuir, 2019, 35(17): 5673-5683. doi:10.1021/acs.langmuir.8b01824http://dx.doi.org/10.1021/acs.langmuir.8b01824

Fukuhara K, Fujii Y, Nagashima Y, Hara M, Nagano S, Seki T. Angew Chem Int Ed, 2013, 52(23): 5988-5991. doi:10.1002/anie.201300560http://dx.doi.org/10.1002/anie.201300560

更多指标>

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Synthesis of Self-demulsification Thermosensitive Polymeric Surfactants and Their Application in Emulsion Polymerization

Stimuli Responsive Nano-objects via Polymerization Induced Self-assembly

Effect of Steric Hindrance on Microphase-separated Structures of Block Copolymers Constructed by Hydrogen Bonding

Self-assembly of Supramolecular Silicon-containing Block Copolymers Based on Hydrogen Bonding Interaction

Related Author

No data

Related Institution

College of Chemical Engineering, Fuzhou University

College of Materials Science and Engineering, Nanjing Tech University

State Key Laboratory of Materials-Oriented Chemical Engineering

College of Biotechnology and Pharmaceutical Engineering

Beijing National Laboratory for Molecular Sciences, Key Laboratory of Polymer Chemistry and Physics of Ministry of Education, Center for Soft Matter Science and Engineering, College of Chemistry and Molecular Engineering, Peking University

Postal code：100190
Tel：010-62588927 Email：gfzxb@iccas.ac.cn
Technical support is provided by Beijing Founder electronics co., LTD 京ICP备05002797号-8 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰